Search results
-
42RLE KJ transmission video
ok, Agree. It worked that way for many years.. why change it, right?- tesuzuki2002
- Post #5
- Forum: How To
-
2003 Liberty w/ 165K miles 42RLE Questions.
Thanks 24turbo for the reply and the info. Perhaps I should have done more of a overhaul rebuild and look at changing out other parts as well. I was mainly targeting the Engine Codes and getting it running again out of Limp mode. For the most part I mainly end up doing freeway...- tesuzuki2002
- Post #3
- Forum: KJ General Discussion
-
2003 Liberty w/ 165K miles 42RLE Questions.
I have had a kick down / bump shift when going from I think 3rd to 2nd for well over a year. A couple months the Trans went into Limp Mode. P0700 Code and the internal diagnostic flagged a P0750 for the L/R Solenoid. I finally got around to getting the parts and doing the job to replace...- tesuzuki2002
- Thread
- Replies: 2
- Forum: KJ General Discussion
-
42RLE KJ transmission video
I know this is a bit old.. but does it actually matter which accumulator piston is which? I just replaced mine and did keep track of them, but they look identical and weigh the SAME amount down to the gram. So I'm genuinely curious what the difference is.- tesuzuki2002
- Post #3
- Forum: How To
-
Fuel Tank Repair - 2003 KJ
Here is an update with pictures of the cut into the gas tank. After doing a bit more research on this. I know my KJ has the 18.5 gallon tank and I'm now seeing that some trim models or in later years there were some with a 20.5 gallon tank. Perhaps this was more on the KK model? Does...- tesuzuki2002
- Post #2
- Forum: KJ General Discussion
-
Fuel Tank Repair - 2003 KJ
I have a 2003 KJ and over the weekend I incurred a gas tank puncture that is at about the 1/2 point of the fuel tank. (I was able to finish out my trip picking up a 2nd Jerry can so could fill up as needed with only about a 140 mile range. I was looking at replacing the fuel tank since...- tesuzuki2002
- Thread
- Replies: 3
- Forum: KJ General Discussion
-
2003 Control Arms and Suspension.
Great thanks for the info. I like that JBA Upper. I think once I get in there and tear it down some of it would just be rebuilding with NEW bushings and hardware. With dong all this work I'll have the option to change out some hardware as I'm going in the direction of a small lift at...- tesuzuki2002
- Post #3
- Forum: KJ General Discussion
-
2003 Control Arms and Suspension.
Hi All, I am going to take on the job of replacing my CV Axles as they appear to giving off a clicking sounds while turning with 4 wheel engages. Upon inspection of starting this I noticed 2 Ball joints boots are damaged an cut open. The front end does not yet show any signs of sloppy...- tesuzuki2002
- Thread
- Replies: 4
- Forum: KJ General Discussion
-
Can’t find the cause of this clicking!!!!!
Dirt... Not exactly soft sand... but Mojave desert sand..- tesuzuki2002
- Post #7
- Forum: KJ General Discussion
-
Can’t find the cause of this clicking!!!!!
Hi, I am experiencing the same thing on my 200 KJ while turning in 4 wheel drive engaged. Both Left and Right and Hi & Low it does it. Completely goes away in 2 wheel drive.- tesuzuki2002
- Post #3
- Forum: KJ General Discussion
