Billwill's latest activity

  • Billwill
    I remove and clean my MAP sensor every few months with Brake Cleaner Spray....the MAP Sensor gets very dirty and you get all sorts of...
  • Billwill
    Billwill replied to the thread No throttle return.
    There is a metal cable going from the pedal into the engine bay where you will see it operates the actual electrical card. Check that...
  • Billwill
    Billwill replied to the thread Fuel Pump -CRD.
    I also have a 2002 2.5L Export CRD. This did not come out with a fuel pump inside the fuel tank so you will not hear a pump running...
  • Billwill
    Billwill replied to the thread Skim pin codes - 06 ?.
    This should work...replacing all those components from the same 05 Jeep model!!
  • Billwill
    Very neat and needed if you do any serious deep-water wading...which I do not! Have you waterproofed your PCM and TCM? Seems to me...
  • Billwill
    Download the Jeep KJ 2003 Service Manuals here: www.colorado4wheel.com/manuals/Jeep/KJ/
  • Billwill
    Billwill replied to the thread Constantly Alarming.
    Does your Export Jeep have a console type box located on the ceiling about dead center inside the Jeep? This is a form of movement...
  • Billwill
    I had a loose connection on the diff sensor on my Export 2002 CRD that stopped the speedometer from working. I fixed the bad connection...
  • Billwill
    Billwill replied to the thread New here from Delaware.
    Yeah I have a 2002 Export CRD from new...love it to bits! Totally agree with you as regards the uncomfortable seats...I have to pad them...
  • Billwill
    Billwill replied to the thread Squealing/grinding noise.
    Is this Export KJ of yours a gasser or a CRD? My 2002 Export 2.5 CRD has 410 gearing in the rear diff and Tracloc which requires the...
  • Billwill
    Billwill replied to the thread 5v at fuel pump.
    Is the battery in good shape? Should not drop below about 10 volts while cranking. Definitely check the main grounding points. Both...
  • Billwill
    Billwill replied to the thread 5 speed manual trans.
    Make sure you use the correct specification gearbox oil...my local Jeep Dealers tried to persuade me that ATF+4 was the correct oil for...
  • Billwill
    Billwill replied to the thread 5 speed manual trans.
    Yeah I have the 5 speed manual gearbox..no problems at all. Is the oil level correct and has the correct gearbox oil? I presume you...
  • Billwill
    Billwill replied to the thread Error codes.
    Yeah those manuals are extremely important! I have them on my Laptop and never travel without my Laptop and Voltmeters etc. in case I...
  • Billwill
    Billwill replied to the thread 4 wheel drive.
    Yeah my sensor on my 2002 Export CRD manual has gone completely dead. I was on a wet muddy steep uphill section and was about to slide...
Top